If you wish to contribute or participate in the discussions about articles you are invited to join SKYbrary as a registered user
From SKYbrary Wiki
Revision as of 10:02, 29 January 2021 by Integration.Manager
An air turnback is a situation where an aircraft returns to land at the departure aerodrome without having initially planned to do so.
The most common reason for air turnback is an emergency or abnormal situation during or shortly after take-off, the most common being engine failure. If the problem happens during acceleration, the crew might attempt to reject the take off depending on the speed and the nature of emergency. Sometimes a safer option is to get airborne and then make an approach and land. A probable complication in this case is that the aircraft's current weight may be greater than the certified maximum landing weight (MLW). If the crew opts for a turnback in this case, there are three options:
- Make an overweight landing. The pilot in command has the right to deviate from prescribed procedures as required in an emergency situation in the interest of safety, i.e. they may choose to land even though the aircraft is heavier than the MLW if they consider this to be the safest course of action. The landing will be more challenging and require longer runway, thus increasing the chance of a runway excursion. Also, a special post-landing inspection will have to be carried out.
- Burning the excess fuel, e.g. by entering a holding pattern. This is a safe option in many cases but if it is considered that by the time the weight is reduced below the MLW the aircraft will no longer be airworthy, or there is another urgent matter (e.g. a medical emergency) another course of action will be taken.
- Dump fuel. This option is not available for most aircraft types and even if it is, the respective system may not have been installed on the particular aircraft. Additional restrictions may also apply, e.g. a minimum level to perform the operation or the need to reach a dedicated fuel dumping area.
Air turnback may happen during all phases of the flight, e.g. climb, cruise or even when the aircraft has reached the vicinity of the destination aerodrome (but is unable to land due to weather conditions). Any significant problem with the aircraft during the climb phase is likely to result in a turnback because of the closeness of the departure aerodrome. During the cruise, if an engine fails (or annother emergency situation arises, e.g. loss of cabin pressure), the flight crew will evaluate the situation and decide on the further course of action. Depending on the circumstances (severity of the situation, available fuel, company policy, weather, etc.), the choice may be to continue to the planned destination, to divert to the planned alternate, to land at the nearest suitable aerodrome or to return to the point of departure.
Accidents and Incidents
- B738, vicinity Paris Orly France, 2018 (On 7 February 2018, a Boeing 737-800 experienced an airspeed mismatch during takeoff on a post maintenance positioning flight but having identified the faulty system by reference to the standby instrumentation, the intended flight was completed without further event. After the recorded defect was then signed off as “no fault found” after a failure to follow the applicable fault-finding procedure, the same happened on the next (revenue) flight but with an air turnback made. The Investigation found that the faulty sensor had been fitted at build three earlier with a contaminated component which had slowly caused sensor malfunction to develop.)
- B773, Singapore, 2016 (On 27 June 2016, a Boeing 777-300ER powered by GE90-115B engines returned to Singapore when what was initially identified as a suspected right engine oil quantity indication problem evidenced other abnormal symptoms relating to the same engine. The engine caught fire on landing. The substantial fire was quickly contained and an emergency evacuation was not performed. The cause of the low oil quantity indication and the fire was a failure of the right engine Main Fuel Oil Heat Exchanger which had resulted in lubrication of the whole of the affected engine by a mix of jet fuel and oil.)
- MD81, vicinity Stockholm Arlanda Sweden, 1991 (On 27 December 1991, an MD-81 took off after airframe ground de/anti icing treatment but soon afterwards both engines began surging and both then failed. A successful crash landing with no fatalities was achieved four minutes after take off after the aircraft emerged from cloud approximately 900 feet above terrain. There was no post-crash fire. The Investigation found that undetected clear ice on the upper wing surfaces had been ingested into both engines during rotation and initiated engine surging. Without awareness of the aircraft's automated thrust increase system, the pilot response did not control the surging and both engines failed.)
- A320, Singapore, 2015 (On 16 October 2015, the unlatched fan cowl doors of the left engine on an A320 fell from the aircraft during and soon after takeoff. The one which remained on the runway was not recovered for nearly an hour afterwards despite ATC awareness of engine panel loss during takeoff and as the runway remained in use, by the time it was recovered it had been reduced to small pieces. The Investigation attributed the failure to latch the cowls shut to line maintenance and the failure to detect the condition to inadequate inspection by both maintenance personnel and flight crew.)
- B38M, en-route, northeast of Jakarta Indonesia, 2018 (On 29 October 2018, a Lion Air Boeing 737-MAX 8 crew had difficulty controlling the pitch of their aircraft after takeoff from Jakarta and after eventually losing control, a high speed sea impact followed. The Investigation found that similar problems had also affected the aircraft’s previous flight following installation of a faulty angle-of-attack sensor and after an incomplete post-flight defect entry, rectification had not occurred. Loss of control occurred because the faulty sensor was the only data feed to an undisclosed automatic pitch down system, MCAS, which had been installed on the 737-MAX variant without recognition of its potential implications.)
- AN26, vicinity Cox’s Bazar Bangladesh, 2016 (On 29 March 2016, an Antonov AN-26B which had just taken off from Cox’s Bazar reported failure of the left engine and requested an immediate return. After twice attempting to position for a landing, first in the reciprocal runway direction then in the takeoff direction with both attempts being discontinued, control was subsequently lost during further manoeuvring and the aircraft crashed. The Investigation found that the engine malfunction occurred before the aircraft became airborne so that the takeoff could have been rejected and also that loss of control was attributable to insufficient airspeed during a low height left turn.)
- Decision Making
- Decision-Making (OGHFA BN)
- Fuel Dumping: Guidance for Flight Crews
- Fuel Dumping - Guidance for Controllers
- Engine Failure: Guidance for Controllers
- Engine Failure After TakeOff - Light Twin Engine Aircraft