If you wish to contribute or participate in the discussions about articles you are invited to join SKYbrary as a registered user

 Actions

MD82, Phuket Thailand, 2007

From SKYbrary Wiki

Summary
On 16 September 2007, an MD-82 being operated by One Two Go Airlines attempted a missed approach from close to the runway at Phuket but after the flight crew failed to ensure that the necessary engine thrust was applied, the aircraft failed to establish a climb and after control was lost, the aircraft impacted the ground within the airport perimeter and was destroyed by the impact and a subsequent fire. Ninety of the 130 occupants were killed, 26 suffered serious injuries and 14 suffered minor injuries.
Event Details
When September 2007
Actual or Potential
Event Type
Human Factors, Loss of Control
Day/Night Day
Flight Conditions VMC
Flight Details
Aircraft MCDONNELL DOUGLAS MD-82
Operator One Two Go Airlines
Domicile Thailand
Type of Flight Public Transport (Passenger)
Origin Bangkok/Suvarnabhumi International Airport
Intended Destination Phuket International
Take off Commenced Yes
Flight Airborne Yes
Flight Completed No
Flight Phase Missed Approach
APR
Location - Airport
Airport Phuket International
General
Tag(s) Approach not stabilised,
Inadequate Aircraft Operator Procedures,
Inadequate Airport Procedures
HF
Tag(s) Authority Gradient,
Fatigue,
Inappropriate crew response (automatics),
Ineffective Monitoring,
Manual Handling,
Procedural non compliance,
Stress
LOC
Tag(s) Loss of Engine Power,
Flight Control Error"Flight Control Error" is not in the list (Airframe Structural Failure, Significant Systems or Systems Control Failure, Degraded flight instrument display, Uncommanded AP disconnect, AP Status Awareness, Non-normal FBW flight control status, Loss of Engine Power, Flight Management Error, Environmental Factors, Bird or Animal Strike, ...) of allowed values for the "LOC" property.,
Aerodynamic Stall
EPR
Tag(s) Airport Emergency Medical Response,
RFFS Procedures
Safety Net Mitigations
Malfunction of Relevant Safety Net No
TAWS Available but ineffective
Outcome
Damage or injury Yes
Aircraft damage Hull loss
Injuries Most or all occupants
Fatalities Most or all occupants ()
Causal Factor Group(s)
Group(s) Aircraft Operation
Safety Recommendation(s)
Group(s) Aircraft Operation,
Airport Management
Investigation Type
Type Independent

Description

On 16 September 2007, a McDonnell Douglas MD-82 being operated by One Two Go Airlines on a scheduled passenger flight from Bangkok to Phuket attempted a missed approach from close to runway 27 in day Visual Meteorological Conditions (VMC) but only climbed briefly before a steep descent into the ground occurred within the airport perimeter. The impact and subsequent fire led to the destruction of the aircraft and to the deaths of 90 of the 130 occupants, serious injury to 26 others and minor injuries to the other 14.

Investigation

An Investigation was carried out by the AAIC of Thailand with significant assistance from the National Transportation Safety Board (USA) (NTSB). The DFDR and Cockpit Voice Recorder (CVR) were recovered and successfully replayed and the non-volatile memory (NVM) from various equipment, including especially the Terrain Avoidance and Warning System (TAWS) unit, also yielded important information.

It was established that the aircraft commander, an Indonesian National, had taken the role of PM for the flight with the First Officer, a much younger Thai National acting as PF. There was a very considerable disparity between the level of both the overall flying experience and the specific aircraft type experience of the two pilots. The First Officer, whilst having been operating on the MD82 for some time, had gained most if not all of his multi crew jet experience on the type.

It was established that the ILS approach in Visual Meteorological Conditions (VMC) had been made with the AP out but the A/T (autothrottle) engaged in conditions which clearly indicated that a temporary deterioration in the weather was imminent and which had included awareness of the preceding inbound aircraft reporting that there “was a Cb over the airport”. Nevertheless, the aircraft commander had allowed the First Officer to remain as PF and even when it became apparent that he was not able to achieve a stabilised approach as the wind velocity and variation increased, did not take control. Eventually, as the auto call out of 40 feet height occurred, an EGPWS Mode 1 Sink Rate Alert was annunciated and the First Officer called a go around. This was confirmed by the commander and the First Officer called for Flap 15 and manually pushed the thrust levers forward - but failed to set or call for TO/GA to be set - before ‘transferring control’ to the commander. Since the A/T was still engaged when the go around was called, retard mode had become active and since the DFDR showed that the thrust had returned to idle after the initial manual override by the First Officer, it was surmised that when control was passed to the commander without prior warning, the First Officer had removed his hand from the thrust levers and the commander was initially using both his hands on the control column. All other go around actions were completed including the necessary pitch up but at no subsequent stage was the TO/GA switch pressed. The aircraft reached a height of almost 300 feet aal before it ceased to climb as a consequence of lack of engine thrust. Further EGPWS alerts and a final PULL UP warning were found to have occurred in the descent shortly before impact, upon which a fire immediately broke out. Four minutes after the impact, the weather had deteriorated further to 800 metres visibility in heavy rain and conditions below landing minima. It was noted that the aircraft had been fitted with a reactive wind shear alerting system which it was established had been serviceable, but no activation of it had occurred until the final second prior to impact.

It was noted that there was no provision in the Operations Manual for a handover of control at the point of go around and considered that confusion about system status would have been exacerbated by this sudden and unplanned / unanticipated handover. It was considered that the aircraft commander could reasonably have taken control at a much earlier stage of the approach and/or called an earlier go around. The Investigation also noted general non compliance with SOPs by the accident aircraft flight crew (although no conflict between them) as well as considerable deficiencies in practices of the aircraft operator. It was also found that both accident flight crew had exceeded various elements of the applicable flight time limitations scheme, although no hard evidence that either was fatigued as a consequence of this in a way that affected the accident outcome was presented by the Investigation.

In respect of the Airport, the effective but non notified unserviceability of the LLWAS due to it being powered by solar cells which had run down after a period of cloudy weather was noted. Aspects of the emergency response were also considered unsatisfactory.

The Commission determined the Probable Causes of the Accident to be as follows:

  • The flight crew did not follow the SOPs (for) Stabilised Approach, Call Out, Go Around and Emergency Situations as specified in the airline’s FOM
  • The Take Off / Go Around (TO/GA) switch was not activated, resulting in the inability of the aircraft to increase in airspeed and altitude during the go around. Also, there was no monitoring of the change in engine power and movement of throttle levers, especially during the critical situation.
  • The flight crew co-ordination was insufficient and the flight crew had heavy workloads.
  • The weather condition changed suddenly over the airport vicinity
  • The flight crew had accumulated stress, insufficient rest and fatigue
  • The transfer of aircraft control took place at a critical moment during the go around

A total of 17 Safety Recommendations were issued as a result of the Investigation as follows:

  • that One Two Go Airlines Company should establish (a) Cockpit Resource Management (Crew Resource Management) course, approved by the DCA, for all related personnel in every concerned section. The course should comprise of initial and recurrent training, having content according to ICAO requirements.
  • that One Two Go Airlines Company should strictly train flight crew according to the flight crew training course and flight procedures in SOP.
  • that One Two Go Airlines Company should amend the Operating Procedures on ‘Transfer of Control during Critical Phase of Flight’ in SOP to be most clear and definite.
  • that One Two Go Airlines Company should perform the pilot training check, as appointed by the DCA, to meet applicable standards, especially the pilot proficiency check.
  • that One Two Go Airlines Company should use a flight simulator that (can) simulate the systems, equipment and instruments of the aeroplane with the same configuration (that) the Airline operates.
  • that One Two Go Airlines Company should arrange the crew schedule, according to the requirements in Flight Time and Flight Duty Period Limitations, by establishing a checking system with advance warning function before exceeding the limitation. The system should also enable the flight crew to check their status.
  • that One Two Go Airlines Company should establish a Safety Management System (Safety Management System) in order to identify and mitigate the risk leading to any accident or incident and to improve the safety of flight operations to meet the required standards.
  • that One Two Go Airlines Company should direct all management levels to encourage personnel to have unique corporate culture in having values and beliefs to perform their jobs, in accordance with laws and regulations, and to report any wrongful misconduct (which) may (be) of use for improving task efficiency and increasing safety performance. This could be done through training and motivation.
  • that the Airport of Thailand Public Company Limited should expedite the improvement of (the) runway strip to meet the Standard prescribed in Annex 14 of ICAO or revise the category of instrument approach procedure to suit the current runway strip. The Company shall also establish a Safety Management System (SMS) in order to identify and mitigate the risk.
  • that in respect of Rescue and Fire Fighting the Airport of Thailand Public Company Limited should construct more access roads across the ditch along runway 27 to inaccessible areas at Phuket International Airport to facilitate rescue and fire fighting team (access) to any accident area in due time. The Company should also arrange the rescue and fire fighting exercise in those areas in order to mitigate the difficulties in rescue and fire fighting.
  • that in respect of Rescue and Fire Fighting the Airport of Thailand Public Company Limited should include the Emergency Medical Institute of Thailand (formerly Narenthorn Centre), which is the government institute that co-ordinate(s) and provide(s) medical emergency service, in the Airport Emergency Plan.
  • that in respect of Rescue and Fire Fighting the Airport of Thailand Public Company Limited should perform a full scale emergency exercise which should cover the participation of all responsible sectors and personnel to comply with the Airport Emergency Plan in (the) most efficient way when an accident (occurs).
  • that the Department of Civil Aviation of Thailand should oversee the operation of One Two Go Airlines Company Limited….in order to improve their safety efficiency. The DCA should also issue regulations indicating the guidelines and practices of CRM training.
  • that the Department of Civil Aviation of Thailand should improve the measure for regulating and overseeing the air operators under DCA supervision to achieve the most efficiency.
  • that the Department of Civil Aviation of Thailand should coordinate with the Aero Thai Company Limited in order to specify operational guidelines (for) ‘Crash on Airport’ into (the) ‘Manual of Air Traffic Services. The guidelines should also be detailed in accordance with Doc 9137/An 898 Airport Service Manual, Part 7: Airport Emergency Planning, Chapter 4, Responsibility and Role of Each Type of Emergency.
  • that the Department of Civil Aviation of Thailand should coordinate with the Meteorological Department to review all LLWAS installation(s) to identify possible deficiencies I performance, similar to those identified at Phuket International Airport and correct such deficiencies to ensure optimum performance of the LLWAS. Furthermore, the DCA should consider the installation of efficient LLWAS with advance system(s) to cover other airports, as considered necessary.
  • that the Department of Civil Aviation of Thailand should coordinate with the following medical centres that perform post accident medical examinations on involved flight crew.
    • The Institute of Aviation Medicine, RTAF to perform physical examination on surviving post accident flight crew.
    • The Institute of Aviation Medicine, RTAF to perform an autopsy and collect samples for laboratory examination by physicians from (the) Ministry of Public Health and/or physicians from the Institute of Forensic Medicine, Royal Thai Police.
    • The Institute of Forensic Medicine, Royal Thai Police to collect and send samples of autopsy to the Institute of Aviation Medicine, RTAF for further laboratory examination, in case(s) where the Institute of Forensic Medicine, Royal Thai Police arrive at the accident site first.
    • The Institute of Forensic Medicine, Royal Thai Police to perform an autopsy and collect samples for laboratory examination with the Institute of Aviation Medicine, RTAF and / or physicians from (the) Ministry of Public Health.
    • The Ministry of Public Health to collect and send samples of autopsy to the Institute of Aviation Medicine, RTAF for further laboratory examination, in case(s) where physicians from (the) Ministry of Public Health arrive at the accident site first.
    • The Ministry of Public Health to perform an autopsy and collect samples for laboratory examination with the Institute of Aviation Medicine, RTAF and / or the Institute of Forensic Medicine, Royal Thai Police.

The Final Report of the Investigation was published in June 2010.

Further Reading